Loctite?

[jacco]

I installed a BMW luggage rack on my R1100R yesterday. It replaces the rear grab rail and attaches with the same bolts as the side case rails. When I took those bolts out to remove the guard rail it appeared as if there was loctite on those bolts. Of course BMW was too cheap to include mounting instructions with my $250 rack, so I wasn't sure if it's smart to add some, and/or what the torque specifications for all the bolts were. If you guys think that I should use loctite, should I use the permanent or semi-permanent kind? Are there torque specifications for these bolts? I don't want to loose my luggage a few months "down the road". Thanks much!

[kbasa]

A little loctite wouldn't hurt. I'd suggest using the stuff that comes apart with hand tools - blue?

[BubbaZanetti]

blue is less "tite" than red

[jacco]

Thanks guys.
Jacco

[bigfoot105]

The red is best for the higher temperatures like exhaust componets but don't use it on engine parts unless the instructions call for it. (I know, who reads the instructions anyway) and the blue for like frame componets.

Hint: Remember,

Red Hot

Blue Ice

[shakyone]

I also own a 2000 R1100R and also installed a luggage rack. Did you happen to notice the weight limit on the rack? I seem to remember that it was only 12 or 14 pounds.

[jacco]

I also own a 2000 R1100R and also installed a luggage rack. Did you happen to notice the weight limit on the rack? I seem to remember that it was only 12 or 14 pounds.

I knew it was low. Didn't remember it was that low. I'll conveniently ignore that spec I guess. The clamps around the rear subframe tubes are pretty sturdy, so I don't see why 20-30 pounds would cause any problems. It's the same with the saddle bags, they also have such a low official weight limit that they'd be practically worthless. I'm not planning to transport lead bricks on my bike, but didn't spend this much $$$ to gain capacity for an extra pair of shoes only. I'm eyeballing the waterproof 51 liter BMW sports softbag. Does anyone have that one? (BMW part number 71 60 7 693 567, around $200).

I'll let you know if I loose it :)

[Bobmws]

The red is best for the higher temperatures like exhaust componets but don't use it on engine parts unless the instructions call for it. (I know, who reads the instructions anyway) and the blue for like frame componets.

Hint: Remember,

Red Hot

Blue Ice

Red is for critical items that you do not want to come apart. It is deactivated by heat, so not for use on exhaust's etc. Paralever bearings come to mind as a place the red is used. For a rack, I would use the blue stuff.

[breyfogle]

blue loctite would not hurt but there is really no reason to use anything at all. Just tighten everything up good and go for a ride.

[jacco]

blue loctite would not hurt but there is really no reason to use anything at all. Just tighten everything up good and go for a ride.

Oh man, now you've done it. My lazy side, rather dominant, will never let me take it apart again! :banghead

[BradfordBenn]

IMHO Blue tastes a little sweeter then Red.

When I was working as a contractor and flying speakers, I always ended up getting some in my mouth, usually from taking off the cap with my teeth. :D

[Boxerkuh]

I would recommend blue locite on the luggage rack and then to periodically to check the bolts. (On my Airhead a needed procedure) You should only use red stuff if you don't want to disassemble it again.
As far as the waterproof bag, I would advise against the BMW bag, unless you are determined that $200 for a 50 liter bag is a good deal. Aerostich sells a large 70 liter bag ro $70, which is waterproof and may by Ortlieb (a German company). They offer small, medium and large; in yellow, black and red. I have the large black one and it is 100% waterproof. Great bag, great value for the money. Check out: www.aerostich.com part number 930, 931 and 932
Hope that helps....

[jacco]

I would advise against the BMW bag, unless you are determined that $200 for a 50 liter bag is a good deal.

Nope :D



Aerostich sells a large 70 liter bag ro $70, which is waterproof and may by Ortlieb (a German company).

Wow, amazing deal! Thanks for the info, clearly a good (better) option. I hope they come with free sunglasses though... :brow